www.fairchildsemi.com
AN-6073
FAN6751 — Highly Integrated Green-Mode PWM Controller
Internal Open-loop Protection
Introduction
GATE Output Maximum Voltage Clamp: 18V
VDD Under-Voltage Lockout (UVLO)
VDD Over-Voltage Protection (OVP)
Internal Recovery Circuit (OVP, OLP)
Internal Sense Short-Circuit Protection
External Constant Power Limit (Full AC Input Range)
Internal OTP Sensor with Hysteresis
Built-in 5ms Soft-Start Function
This application note describes a detailed design strategy for
a high-efficiency, compact flyback converter. Design
considerations and mathematical equations are presented as
well as guidelines for a printed circuit board layout. The
highly integrated FAN6751 series of PWM controllers
provides several features to enhance the performance for
LCDM/TV, NB, and adapters.
The green-mode function includes off-time modulation and
burst mode to reduce the PWM frequency at light-load and
in no-load conditions. To avoid acoustic noise problems, the
minimum PWM frequency is set above 18KHz. This green-
mode function enables the power supply to meet
international power conservation requirements. With the
internal high-voltage startup circuitry, the power loss due to
bleeding resistors is also eliminated. Built-in synchronized
slope compensation achieves stable peak-current-mode
control. The proprietary external line compensation ensures
constant output power limit over a wide AC input voltage
Built-in VIN Pin Pull HIGH (> 4.7V) Recovery
Function for Second-Side Output OVP
Brownout Protection with Hysteresis
Applications
General-purpose, switch-mode power supplies and flyback
power converters, including:
range, from 90VAC to 264VAC
.
Power Adapters
Open-frame SMPS
LCD Monitor/TV
FAN6751 provides many protection functions, as shown in
Table 1. In addition to cycle-by-cycle current limiting, the
internal open-loop protection circuit ensures safety should
an open-loop or output short-circuit failure occur.
SOP-8
Features
High-Voltage Startup
GND
FB
1
2
3
4
8
7
6
5
GATE
VDD
Low Operating Current: 4mA
Linearly Decreasing PWM Frequency to 18KHz
Fixed PWM Frequency: 65KHz
Peak-Current-Mode Control
NC
HV
SENSE
VIN
Cycle-by-Cycle Current Limiting
Leading-Edge Blanking (LEB)
Synchronized Slope Compensation
Figure 1. Pin Configuration (Top View)
Table 1. Protection Functions of FAN6751 Series
Pull-High
Protection (VIN)
OTP
(Internal)
SCP
(SENSE)
PWM
Frequency
Part Number
OVP (VDD)
OLP (FB)
FAN6751MRMY
FAN6751HLMY
Recovery
Latch
Recovery
Latch
Recovery
Latch
Recovery
Recovery
Recovery
Recovery
65KHz
100KHz
© 2008 Fairchild Semiconductor Corporation
Rev. 1.0.0 • 9/26/08
www.fairchildsemi.com