TM
5E Series
25-30W DC-DC Converters
Specifications
Operating Temperature Range…………………………-25º C ~ +71º C
Case Temperature………………………………………….100 º C max.
Cooling……………………………………………….Free air convection
Storage Temperature Range……………………..…..-55 º C ~ +105º C
Isolation Voltage………………………….………………..500VDC min.
EMI/RFI…………………………………….....Six-sided continus shield
Dimensions…………………2.65” x3” x 0.83 “(65 x 76.2 x 21.1 mm)
Case Material……..Black Coated Copper with Non-conducted base
Input Specifications:
Input Voltage Range…………….……12V……...………………..9-18V
24V……………………..18-36V
48V…………………......36-72V
Input Filter………………………………………………………..Pi Type
Output Specifications:
Voltage Accuracy
Single output………………………..…………………….+/- 1.0 % max.
Daul output………………………………………………..+/- 3.0 % max.
Triple, 5V………………………………………………….+/- 1.0 % max.
12V/15V/ -5V……………………………………..………+/- 3.0 % max.
Voltage Balance ( Dual )………………………………...+/- 1.0 % max.
External trim Adj. Range……………………………..…………+/- 10%
Ripple & Noise, 20 MHz BW……………………….… 75 mV p-p max.
Temperature Coeffcient………………………… +/- 0.02 % /º C max.
Short Circuit Protection………………………………..……Continuous
Line Regulation ¹ Single / Dual Output………….……..+/- 0.2 % max.
Triple………………………….………..+/- 1.0% max.
Load Regulation ² Single / Dual Output…………….….+/- 1.0 % max.
Triple………………………..…………+/- 5.0 % max.
General Specifications :
Triple output loading table
Ouput
(pin no.)
6
3 & 5
3 & 5
3 & 5
Voltage
(V)
+5
+12 or -12
+15 or -15
+12 or -5
Amperes
Min. (2)
0.25
0.1
Nom.
1.5
0.31
0.1
0.25
0.1/0.1
0.31/0.5
Note: 1. measured from high lin to low line
2. measured from full load to ¼ load
3. maximum total power from all outputs is limited to 25/30W
but no output should be allowed to exceed its maximum current
4. minmum current on each output is required to maintain
specified regulation
Efficiency………………………………………………..……..see table
Isolation Resistance…………………………………………..100Mohm
Switching Frequency……………………………………..200 KHz, min.
Outline Information and Pin-out
Pin Connection
Pin
1
2
Single
+Input
-Input
Dual
+Input
-Input
Triple
+Input
-Input
3
4
5
6
No pin
Trim
No pin
+Output
-Output
+Output
Common
-Output
No pin
No pin
+Output
Common
-Output
+5V output
No pin
7
8
Remote On/Off Control
Remote On/Off Control
Logic compatibility
Ec -0n
Ec -Off
CMOS or Open collector TTL
>5.5 Vdc or open circuit
<1.8 Vdc
Shutdown Idle current
Input resistance
Control common
10mA
100K ohms (Ein 0Vdc to 9Vdc)
referenced to Input minus
External Output Trimming
Output may optionally be externally trimmed (+/-10%) with a fixed
resistor or an external trimpot as shown.
Broadband TelCom Power, Inc. – 1719 S. Grand Avenue, Santa Ana, CA 92705 U.S.A.
Tel.: 714-259-4888 • Fax: 714-259-0840• www.btcpower.com • Email: sales@btcpower.com DS LP 5E Rev2 16-1-04