PRODUCT BRIEF
Power PROFET™ + 24/48V
Ultra low-ohmic smart high-side switches in TOLL package
The Power PROFET™ + 24/48V smart high-side switch family provides a very
low RDS(on) – one variant down to 1.5 mΩ – in a small 8-pin leadless power
package (HSOF-8). The ability to drive high current loads up to 35 amperes
and its state of the art integrated protections and diagnosis features makes
Power PROFET™ + 24/48V ideally suited to replace electromechanical relays,
fuses and discrete circuits in power distribution and other high current
applications in a 24 V or 48 V board net.
Key features
‒ 24/48 V lowest-ohmic high side
switches with integrated pro-
tection and diagnosis features
‒ Extended voltage range
8 … 60 V
‒ Protection: short-circuit
with latch, overtemperature
with latch, smart clamping,
overpower shutdown, ground
loss protection
Severe automotive requirements like load dump, short circuit, low battery
voltage during the cranking and low impact on EMC in PWM operation are
fully met. The current (dkILIS) accuracy especially at low current allows a
reliable diagnosis feature at system level.
‒ Load dump robustness up to
70 V
‒ Diagnosis: load current sense
output and short circuit,
overtemperature, open load
detection on/off state
The Power PROFET™ + 24/48V devices are automotive qualified and PRO-SIL™
ISO 26262-ready and come with a safety application note to facilitate the
usage in functional safety-related applications.
Block diagram
‒ Diagnosis Enable Pin (DEN) for
MCU input multiplexing
VS
Smart
clamp
Voltage
sensor
Temperature
sensor
Key benefits
‒ Fully integrated solution with
low stand-by current (7 µA)
‒ Supports long wires
‒ Leadless power package with
good thermal performance
‒ Outstanding current sense
accuracy 5ꢀ aꢁer calibration
‒ Very low offset on the current
sense: for high accuracy at low
load current
Driver
logic
Gate control
and
Overcurrent
switch-off
charge pump
OUT
IS
IN
ESD
Load current
sense
ESD
protection
DEN
protection
GND
Key applications
‒ Fuse and relay replacement
‒ Heating: rear defogger, glow
plugs and PTC
‒ Fan and pump
‒ Power distribution
ꢀwww.infineon.com/powerprofet