TOCOS CODED SWITCHES
TP7
TP7 CODED SWITCHES (Absolute Encoders)
1. For Pro-use. Channel selector is preset to
assigned frequencies:
TP70TF5161 (Single shaft, Triple unit, 16 channels)
TP70TF5161
Electrical Characteristics
Specification
Conditions
• Contact resistance
• Dielectric strength
ON: 1Ω max. OFF: 1MΩ min.
No dielectric breakdown
Detent position
300VAC at 1 minute
Between terminal - case
Between terminal - shaft
250VDC at 1 minute
Between terminal - case
Between terminal - shaft
• Insulation resistance
100MΩ min.
Mechanical Characteristics
Specification
9.8-58.8mN m (100-600gf cm)
Conditions
• Operating force
•
•
19.6-39.2mN m (200-400gf cm) for P’GRID products
•
•
2 CH
3 CH
4 CH
8 CH
16 CH
ꢁ
30ꢀ 3ꢀ
ꢁ ꢁ ꢁ
22.5ꢀ 3ꢀ *20ꢀ 3ꢀ 22.5ꢀ 3ꢀ
• Step angle
ꢁ
30ꢀ 5ꢀ
ꢁ
ꢁ ꢁ ꢁ
90ꢀ 5ꢀ 157.5ꢀ 5ꢀ *300ꢀ 5ꢀ Endless
• Rotational angle
• Terminal strength
60ꢀ 5ꢀ
No damage to case and terminal fall-off
Bent terminals shall be acceptable
No abnormality to be seen in electrical characteristics
after testing
Static load of 4.9N (0.5kgf )
shall be applied to the tip of the
terminals for 15 secs. in vertical
direction (1 time/terminal)
Static load
• Strength
Shaft pull: 98.1N min. (10kgf min.)
Shaft push: 98.1N min. (10kgf min.)
Nut tightening: 0.98N m min. (10kgf cm min.)
•
•
• Soldering heat resistance
• Shaft stopper strength
• Shaft wobble and bend
There shall be no mechanical abnormality
such as excessive play
Soldering iron: 3 sec. max.
ꢁ
at 350ꢀ 5ꢀ
0.39N m min. (4kgf cm min.)
•
•
Not applicable for products with endless rotational angle.
Radial: 0.5ꢂ shaft length/30mm max. (single shaft/dual outer shaft)
Radial: 0.7 ꢂ shaft length/30mm max. (dual inner shaft)
Thrust: 0.5mm max. 2.5N (250gf ) applied to tip of the shaft
Durability Characteristics
Specification
Conditions
• Life (without load)
5,000 cycles
30,000 cycles for P’GRID products
Contact resistance (ON): 10Ω max.
Contact resistance (OFF): 1MΩ min.
ꢄ
• Operating temperature range
• Shaft Seal
(Optional O-ring seal between
the bushing and shaft)
ꢃ20ꢀC to 70ꢀC
After mounting a coded switch to a panel and exposing it to water
under a maximum hydraulic pressure of 9.8kPa (0.1kgf/cm2) for
30 minutes, there shall be no leak between the shaft and bushing (IP67).
(
) Also applies to P’GRID products.
*
ꢅ All products in this catalog are not for use in life support equipment.
TP/RH Series are NOT board washable.
31
1177 East Tower Road, Schaumburg, IL 60173 Tel: 847-884-6664 Fax: 847-884-6665 E-mail: sales tocos.com www.tocos.com
@